(1. 山東理工大學 資源與環境工程學院，淄博 255000；
2. 山東華特磁電科技股份有限公司 磁電工程技術中心，臨朐 262600)
摘 要: 在油酸浮選鋰輝石體系中分別加入Ca2+、Al3+、Fe3+離子，通過單礦物浮選試驗、金屬離子吸附量檢測、金屬離子水解組份濃度計算、礦物表面動電位測試、紅外光譜檢測以及量子化學模擬計算研究Ca2+、Al3+、Fe3+離子對鋰輝石浮選的活化行為和作用機理。結果表明：Ca2+離子的最佳活化區間為pH大于12的強堿性條件，Al3+離子的最佳活化pH為6.47，而Fe3+離子的最佳活化pH為7.25；在這些pH區間內，鋰輝石浮選回收率和金屬離子吸附量均達到最大值。在鋰輝石浮選過程中起活化作用的有效組份為它們分別對應的氫氧化物沉淀。Ca2+、Al3+、Fe3+離子可使鋰輝石表面動電位向正值方向顯著偏移；Ca2+離子在鋰輝石表面雙電層的外層發生靜電吸附，Al3+和Fe3+離子在鋰輝石表面雙電層的內層發生特性吸附。鈣原子與鋰輝石礦物表面吸附后形成的Ca—O鍵的鍵強較小，以離子鍵為主；鐵原子與礦物表面形成Fe—O化學鍵的鍵強較大，含有一定的共價鍵組份；而鋁原子與礦物表面吸附后形成的Al—O鍵的鍵長、鍵強等參數介于鈣、鐵的參數之間。油酸在Ca2+活化后的鋰輝石表面發生了化學吸附和少量的物理吸附，而在Al3+、Fe3+活化后的鋰輝石表面發生了較為強烈的化學吸附。
關鍵字: 金屬陽離子；活化作用；鋰輝石浮選；水解溶液化學
（1. School of Environment and Resources Engineering, Shandong University of Technology, Zibo 255000, China;
2. Magnetoelectric Engineering Technical Center, Shandong Huate Magnetoelectricity Science and Technology Ltd., Linqu 262600, China）
Abstract:Ca2+, Al3+, Fe3+ ions were added as activator into spodumene flotation system using collector of oleic acid. The activation performance and mechanism of Ca2+, Al3+, Fe3+ ions on spodumene flotation were investigated by single mineral flotation experiments, metal ion adsorption detection, calculation of solution chemistry of metal ions, zeta potential measurements, infrared spectroscopy analysis and quantum chemical simulation calculation. The results show that the optimum activation range of Ca2+ is in strong alkaline condition with pH greater than 12, the optimum activation pH of Al3+ is 6.47, and the optimum activation pH of Fe3+ is 7.25. Within these pH ranges, the recovery of spodumene flotation and the adsorption capacity of metal ions reach the maximum value. The dominant active components are hydroxide precipitation of Ca2+, Al3+, Fe3+ ions accordingly. The ions can make the surface potential of spodumene shift significantly to the positive direction. Ca2+ ions are adsorbed on the outer layer of the electric double layer on the surface of spodumene by electrostatic adsorption, while Al3+ and Fe3+ ions are adsorbed on the inner layer of the electric double layer by specific adsorption. Ca—O bonds formed by the adsorption of calcium atoms on the surface of spodumene minerals are weak, mainly in the form of ion bonds. The bond strength of Fe—O bonds is strong and contained certain covalent bond components, while the bond length and bond strength of Al—O bonds formed by adsorption of Al atom on mineral surface are between those of Ca and Fe. It is chemical and faint physical reaction by which oleic acid is adsorbed on the Ca2+ activating spodumene surface, and the strong chemical adsorption occurs on the surface of spodumene activated by Al3+ and Fe3+.
Key words: metallic cations; activation behavior; spodumene flotation; hydrolysis solution chemistry
