(廣州有色金屬研究院 資源綜合利用研究所，廣州 510651)
摘 要: 通過浮選實驗、吸附量測定、Zeta電位測試、羥肟酸與Ca2+作用模型的建立以及紅外光譜測試，研究羥肟酸對白鎢礦的浮選作用機理。結果表明：當pH為8~10時，白鎢礦具有很好的可浮性，且在pH=9時達到最大回收率，其中環已甲基羥肟酸(CHA)對白鎢礦的捕收能力優于BHA的；在整個實驗pH范圍內(8~10)，CHA在白鎢礦表面的吸附量均大于苯甲羥肟酸(BHA)的，CHA的加入使白鎢礦表面動電位向負移動的程度要大于BHA的，且CHA與Ca2+的結合能更負，這均說明CHA更容易在白鎢礦表面發生吸附，對白鎢礦的捕收能力更強；BHA在白鎢礦表面發生牢固的化學吸附，與鈣離子作用生成了BHA鈣鹽。
關鍵字: 白鎢礦；羥肟酸；浮選機理
（Research Institute of Resources Comprehensive Utilization,
Guangzhou Research Institute of Non-ferrous Metals, Guangzhou 510651, China）
Abstract:The flotation mechanism with hydroxamic acid of scheelite were researched by floatation experiment, adsorption measurement, Zeta potentiodynamic measurement, modeling of hydroxamic acid and Ca2+ and infrared spectrum measurement. The flotation experiment of scheelite show that scheelite has good flotability when pH is 8-10 and has maximum recovery especialy when pH=9. CHA has stronger collecting ability than BHA. At the whole range of pH (8-10), the adsorption amount of CHA is more than that of BHA, the negative moving degree of scheelite surface potentiodynamic added with CHA is more than BHA, binding energy between CHA and Ca2+ is more negative, which show that CHA is adsorbed easily on the scheelite surface and possesses stronger collecting ability. The chemical adsorption of BHA occurs firmly on the surface of scheelite, the BHA calcium generates after interacted with calcium ions.
Key words: scheelite; hydroxamic acid; flotation; mechanism
